FIKO 70 Nostalgia-B
28Pages

FIKO 70 _________________________________________________________________________________________ Installation and Operation Manual solid fuel cooker FIKO 70 tested according to the standard EN 12815 ________________________________________________________________________________________________________ 1. GENERAL The solid fuel cooker has been designed for home cooking and baking. It has been conceived to burn wood and lignite briquettes. The cooker can be installed in common premises defined by the Slovak national standard STN 33 0300. Make sure that all local regulations, including those concerning national and European standards, are respected during installation. Inform your chimney-sweep prior to cooker installation to have an expert check of the cooker connection to your chimney made. Make sure that the floor where the cooker will be installed has adequate bearing capacity. When installing, make sure there will be easy access for cleaning the cooker, the flue way, and the chimney. The cooker must be closed whether in use or out of use, otherwise operation of other equipments connected to the chimney may be affected. CAUTION: For commands of spare parts or complaints, please give the designation, model, and reference number mentioned in the data card! 2. TECHNICAL DATA AND FEATURES The cooker can be connected to the chimney from the side and the models FIKO 70 Ratio, FIKO 70 Plus and FIKO Nostalgia B from the top. Versions: right and left hand side, legs mounted (FIKO 70) and unmounted (FIKO 70 A, FIKO 70 Nostalgia, FIKO 70 Nostalgia B, FIKO 70 Ratio, FIKO 70 Plus) with protective frame of the cook-top (FIKO 70 Nostalgia, FIKO 70 Nostalgia B) Nominal capacity: 6.5 kW Nominal heating capacity efficiency: wood = 75.2 %, lignite briquettes = 80.8 % Operating chimney draft: 12 Pa Worktop height 800 mm Cooker width 750 mm, Nostalgia, Nostalgia B = 860 mm Cooker depth 600 mm, Nostalgia, Nostalgia B = 655 mm Draught shaft diameter: Ø120 mm Dimension up to the lower edge of the draught shaft: 635 mm, Ratio, Plus and Nostalgia B with outlet on the cook-top Weight FIKO 70, FIKO 70A = 71 kg, FIKO 70 Nostalgia, FIKO 70 Nostalgia B = 74 kg, FIKO 70 Ratio, FIKO 70 Plus = 70 kg Dimensions of the oven: Width: 334 mm Depth: 455 mm Height: 234 mm Area of the cook-top: 0.34 m2, models Nostalgia B, Ratio,Plus and Nostalgia = 0,30 m² Recommended fuel: dry hard wood - approximate heating value 15 MJ.kg-1 lignite briquettes - approximate heating capacity 20 ÷ 23 MJkg-1 Approximate consumption of recommended fuel at nominal capacity: wood: 2.2 kg.hod.-1 lignite briquettes: 1.7 kg.hod.-1 Applicable standards: STN 06 1201, EN 12815, STN 73 4201, STN 73 4210, STN 92 0300 3. INSTALLING THE COOKER Pursuing to the regulation Nr. 401/2007, all related drawing, security, and hygiene directives must be respected during installation. For cookers with unmounted legs (to be found in the ash box in such case) legs are to be mounted with screws, bolts and washers supplied with them in the ash box. Each leg should be mounted on the cooker with: a) one screw and two elastic washers: applies to versions FIKO 70, FIKO 70 A, FIKO 70 Nostalgia and FIKO 70 Nostalgia B b) three bolts: applies to version FIKO Ratio and FIKO 70 Plus Prior to connecting the cooker, make sure that the chimney draught is adequate. The flame of a burning paper or candle shall be draught towards the chimney opening. The cooker connection to the chimney flue must be as short as possible. According to Slovak national standards STN 73 4210 and STN 73 4201, the connection of the cooker to the draught hole must be approved by a chimney-sweep company concerned. Shall the direct connection of the cooker to the chimney flue be impossible, the respective flue pipes should be as short as possible and rise towards the chimney. Maximum flue pipes length is 1.5 m. In any case the bend pipe or the pipe connected to the draught shaft must be secured against loosening with a dowel. Smoke pipes and bend pipes connections must be firm and tight, the pipes being stuffed one into another at minimum 40 mm draught-wards. The chimney opening must be furnished with metal sleeve with a diameter corresponding to the one of the smoke pipes. See correct and incorrect connection of the cooker to the chimney in the picture no. 1. 1.

Fig. 1 Connection to the chimney incorrect - correct 4. SAFETY MEASURES The STN 92 0300 fire protection guidelines must be respected during installation. If flammable construction materials and objects of flammability classes B, C1, or C2 by STN 73 0823 in proximity, the wood heater and the respective flue pipe must be installed in a safe distance which is at least 600 mm on the sides and 300 mm from the rear face of such objects. The safety distance is double if the cooker with the flue way were in proximity of materials of flammability class C3. The same applies to cases when flammability...

Burning lignite briquettes: Nominal heating capacity can be obtained with 3 lignite briquettes (approx. 1.7 kg). Use the rotary primary air slider on the ash box door to control the fire. Ash box door must be kept shut. Pots used for cooking should have a massive and flat bottom and a suitable lid. The cook-top lid must not be removed when cooking. Firing flap valve must be set on position 1 (= open), oven door must be open. Cooking: Wood is the most suitable fuel for cooking (temperature is maintained easier than with other fuels), cooking conditions are even better when small quantities...

FIKO 70 _________________________________________________________________________________________ 13. PRECAUTIONS The wood heater cannot be operated under conditions increasing the risk of generating flammable gases, fire or explosion risk (e.g. laying a floor with an adhesive etc.). - This instruction must be followed when operating the cooker. -The cooker can be operated by adults only. It is unacceptable to let children in front of an operational wood heater. - No flammable liquids are accepted for firing. - IT IS STRICTLY FORBIDDEN TO INCREASE THE NOMINAL CAPACITY DURING THE OPERATION...