NAPOLEON - PRESTIGE 500
56Pages

This gas grill must be used only outdoors in a well-ventilated space and must not be used inside a building, garage, screened-in porch, gazebo or any other enclosed area. APPLY SERIAL NUMBER LABEL FROM CARTON Do not try to light this appliance without reading the “LIGHTING” instructions section of this manual. IF YOU SMELL GAS: • Shut off gas to the appliance. • Extinguish any open flame. • Open lid. • If odor continues, keep away from the appliance and immediately call your gas supplier or fire department. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. An L.P. cylinder not connected for use must not be stored in the vicinity of this or any other appliance. If the information in these instructions is not followed exactly, a fire or explosion may result, causing property damage, personal injury or death. Adults and especially children should be alerted to the hazards of high surface temperatures. Young children should be supervised near the gas grill. Notice to Installer: Leave these instructions with the grill owner for future reference. Wolf Steel Europe BV De Riemsdijk 22, 4004 LC, Tiel The Nederlands eu.info@napoleon.com N415-0518CE-GB-DE AUG 05.20

*Conditions and Limitations This Limited Warranty creates a warranty period as specified in the aforementioned table, for any product purchased through an authorized NAPOLEON dealer, and entitles the original purchaser to the specified coverage in respect of any component replaced within the warranty period, either by NAPOLEON or an authorized NAPOLEON dealer, to replace a component of such product that has failed in normal private use as a result of a manufacturing defect. The “50% off” indicated in the table means the component is made available to the purchaser at a 50% discount off the...

WARNING! Failure to follow these instructions could result in property damage, personal injury or death. Read and follow all warnings and instructions in this manual prior to operating grill. Safe Operating Practices This gas grill must be assembled exactly according to the instructions in the manual. If the grill was store assembled, you must review the assembly instructions to confirm correct assembly and perform the required leak tests before operating the grill. Read the entire instruction manual before operating the gas grill. Under no circumstance should this gas grill be modified....

P500-3 GRILL GRILL SIZE: 3200 sq.cm WARMING RACK SIZE: 1680 sq. cm ALL DIMENSIONS ARE APPROXIMATE 168 cm 137cm - RSIB SHELF FOLDED 106cm - NON RSIB SHELVES FOLDED 67 cm 127 cm 147 cm-LID OPEN 94 cm GRILL HEIGHT

Correct Disposal Of This Product This marking indicates that this product should not be disposed with other household wastes throughout the EU. To prevent possible harm to the environment or human health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources. To return your used device, please use the return and collection systems or contact the retailer where the product was purchased. They can take this product for environmental safe recycling. Use only gas cylinders, which meet national and regional codes. For optimal performance...

WARNING! • Do not route hose underneath drip pan. • Do not route hose between space in bottom shelf and back panel. • Do not route hose over top of back panel. • Ensure all connections are tightened using two wrenches. Do not use Teflon tape or pipe dope on any hose connection. • Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. • Do not use enclosure to store excess hose, as there is a greater chance of the hose contacting a hot surface, it may melt and leak causing a fire. The following table lists input values for the appliance....

This unit includes an internal regulator which stabilizes the gas pressure and improves grill performance. This regulator cannot be adjusted. There is a pressure tap located on the side of the regulator. It can be used by a qualified service person when servicing the grill to determine if the regulator is functioning properly. The screw within the pressure tap must always be kept tight, except when performing a pressure test on the regulator (qualified service personnel only). Leak Testing Instructions WARNING! A leak test must be performed annually and each time a cylinder is hooked up or...

Lighting Instructions www.napoleon.com Main Burner Lighting NOTE! Do not use rear burner while operating main burner. N415-0518CE-GB-DE AUG 05.20

Cooking Instructions Initial Lighting: When lit for the first time, the gas grill emits a slight odor. This is a normal temporary condition caused by the “burn-in” of internal paints and lubricants used in the manufacturing process and does not occur again. Simply run the main burners on high for approximately one-half hour. Do not locate this gas grill in windy settings. High winds adversely affect the cooking performance of the gas grill. In extreme circumstances when consistent high winds come from directly behind the unit, heat can vent underneath the control panel. This may cause the...

Infrared Side Burner Use: The gas grill should be located so that the side burner is protected from the wind, because the wind will adversely affect its performance. The recommended pan diameter is 250 to 300 mm. The side burner is equipped with a cooking grid which can be positioned at two different heights. The lower position can be used like any range top burner, for gravies, soups, etc. The higher position is for searing meats. (see instructions located on side burner lid). WARNING! Do not close the side burner lid while it is operating or hot. WARNING! Do not adjust cooking grid while...

Infrared Heat Most people don’t realize that the heat source we are most familiar with, our sun, warms the earth using mainly infrared energy. This is a form of electro-magnetic energy with a wavelength just greater than the red end of the visible light spectrum but less than a radio wave. This energy was discovered in 1800 by Sir William Herschel who dispersed sunlight into its component colors using a prism. He showed that most of the heat in the beam fell into the spectral region just beyond the red end of the spectrum, where no visible light existed. Most materials readily absorb...